Journal of Research in Environmental Health

Journal of Research in Environmental Health

Evaluation of the Efficiency of Advanced Oxidation Process Based on Catalytic Ozonation in the Presence of Synthesized Zinc Oxide (Zno) Nanoparticles in the Removal of Volatile Organic Compounds (Vocs) in Polluted Air

Authors
Amir Shojaei 1
Hossein Ghafourian 1
Linda Yadegarian 1
Kamran Lari 2
Mohammadtaghi Sadatipour 1
1 Islamic Azad University, North Tehran Branch, Faculty of Marine Science and Technology
2 Department of Physical Oceanography, North Tehran Branch, Islamic Azad University
10.22038/jreh.2021.56252.1410
Abstract
Abstract
Background and Aim :The release of volatile organic compounds from stationary and mobile sources increases the concentration of these compounds in the environment. These compounds are potentially hazardous to the environment and human health. The selection of management and engineering systems has become essential for controlling the release of these pollutants. The aim of this study was to use an advanced catalytic ozonation process to reduce the concentration of these pollutants in industrial emissions.
Materials and Methods:In this experimental study, the ozonation process in the presence of a catalyst bed containing ZnO nanocomposites coated on zeolite was used to treat the air contaminated with BTEX compounds as indicators of volatile organic compounds on a laboratory scale. In this study, the synthesis of nanocomposites was done using the chemical co-deposition method. SEM, XRD, BET, and FT-IR analyses were performed to investigate the structural properties of the nanocomposites. The initial concentrations of BTEX (50-200 ppm), the flow of the polluted air (5-20 l/h), humidity (0-75%), and ozone dose (0.25-1 g/h) were studied. The concentration of the BTEX compounds was measured by a Gas Chromatography (GC) device according to the NIOSH Guideline 1501.
Results:The results of SEM, XRD, BET, and FT-IR indicated the proper synthesis of nanocomposites. Based on the laboratory results, the optimal process conditions were the initial concentration of pollutants equal to 50 ppm, the inlet flow rate of polluted air equal to 5 l/h, relative humidity of 25-35%, and the inlet concentration of ozone equal to 1 g/h. Under these conditions, the removal efficiencies of benzene, toluene, ethylbenzene, and xylene were 98, 96, 92, and 91%, respectively. Simple ozonation and adsorption processes had lower efficiencies than catalytic ozonation and the synergistic effect of the process was evident.
Conclusion:Based on the obtained results, the process has the ability to reduce the concentration of BTEX compounds to the specified standards. This process can be used to treat polluted air in BTEX emitting industries that threaten human health and the environment.
Article type:Research article
Keywords: Volatile Organic Compounds; BTEX; Nanocomposite; Zinc Oxide; Ozone; Polluted Air
Keywords
Volatile Organic Compounds
BTEX
Nanocomposite
Zinc Oxide
Ozone
  1. Tuet WY, Chen Y, Xu L, Fok S, Gao D, Weber RJ, et al. Chemical oxidative potential of secondary organic aerosol (SOA) generated from the photooxidation of biogenic and anthropogenic volatile organic compounds. Atmospheric Chemistry and Physics. 2017;17(2):839-53.
  2.  Jiang Z, Grosselin B, Daële V, Mellouki A, Mu Y. Seasonal and diurnal variations of BTEX compounds in the semiurban environment of Orleans, France. Science of the Total Environment. 2017;574:1659-64.
  3.  Hosinzadeh E, Samarghandi MR, Faghih MA, Roshanaei G, Hashemi Z, Shahidi R. Study of volatile organic materials concentrations (BTEX) and electromagnetic fields in printing and copying centers in Hamadan. 2012.
  4.  Hajizade Y, Nazmara S, Teiri H, Parseh I. Determination of Volatile Organic Compounds (VOCs) and Total Hydrocarbons (THCs) in ambient air of a petrochemical complex in Iran and their urinary metabolites in employees. Iranian Journal of Health and Environment. 2017;10(1):103-14.
  5.  Maulini-Duran C, Puyuelo B, Artola A, Font X, Sánchez A, Gea T. VOC emissions from the composting of the organic fraction of municipal solid waste using standard and advanced aeration strategies. Journal of Chemical Technology & Biotechnology. 2014;89(4):579-86.
  6. Shu Y, Xu Y, Huang H, Ji J, Liang S, Wu M, et al. Catalytic oxidation of VOCs over Mn/TiO 2/activated carbon under 185 nm VUV irradiation. Chemosphere. 2018.
  7.  Della Pina C, De Gregorio MA, Clerici L, Dellavedova P, Falletta E. Polyaniline (PANI): an innovative support for sampling and removal of VOCs in air matrices. Journal of hazardous materials. 2018;344:308-15.
  8. Yang C, Qian H, Li X, Cheng Y, He H, Zeng G, et al. Simultaneous Removal of Multicomponent VOCs in Biofilters. Trends in biotechnology. 2018.
  9.  Isaacman-VanWertz G, Massoli P, O’Brien R, Lim C, Franklin JP, Moss JA, et al. Chemical evolution of atmospheric organic carbon over multiple generations of oxidation. Nature chemistry. 2018;10(4):462.
  10. Nigar H, Julián I, Mallada R, Santamaría J. MicrowaveAssisted Catalytic Combustion for the Efficient Continuous Cleaning of VOC-Containing Air Streams. Environmental science & technology. 2018;52(10):5892-901.
  11.  Kasih TP. Investigation of the Non-Thermal Plasma-Based Advanced Oxidation Process for Removal of Organic Contaminants In Azo Dyes Solution. Journal of Ecological Engineering. 2017;18(2).
  12.  Wang LK, Hrycyk O, Kurylko L. Removal of volatile compounds and surfactants from liquid. Google Patents; 1992.
  13.  Bellamy WD, Hickman GT, Mueller PA, Ziemba N. Treatment of VOC-contaminated groundwater by hydrogen peroxide and ozone oxidation. Research Journal of the Water Pollution Control Federation. 1991:120-8.
  14.  Chen C, Bai H, Chang S-m, Chang C, Den W. Preparation of N-doped TiO 2 photocatalyst by atmospheric pressure plasma process for VOCs decomposition under UV and visible light sources. Journal of Nanoparticle Research. 2007;9(3):365-75.
  15.  Wang L, Liu L, Yang F. Efficient gas phase VOC removal and electricity generation in an integrated bio-photo-electrocatalytic reactor with bio-anode and TiO2 photo-electrocatalytic air cathode. Bioresource Technology. 2018.
  16.  Maleki H, Hüsing N. Aerogels as promising materials for environmental remediation—A broad insight into the environmental pollutants removal through adsorption and (photo) catalytic processes. New Polymer Nanocomposites for Environmental Remediation: Elsevier; 2018. p. 389436.
  17.  Kıcık H, Eren HA. Application of ozone gas for the stripping of fabric ink-jet-printed with reactive dyes. Coloration Technology. 2017;133(6):485-90.
  18.  Li W, Zhou Q, Hua T. Removal of organic matter from landfill leachate by advanced oxidation processes: a review. International Journal of Chemical Engineering. 2010;2010.
  19. Li Z, Zhao H, Han H, Liu Y, Song J, Guo W, et al. Graphenesupported ZnO nanoparticles: an efficient heterogeneous catalyst for the Claisen-Schmidt condensation reaction without additional base. Tetrahedron Letters. 2017;58(42):3984-8.
  20.  Kołodziejczak-Radzimska A, Jesionowski T. Zinc oxide— from synthesis to application: a review. Materials. 2014;7(4):2833-81.
  21.  Guo F, Shi W, Guan W, Huang H, Liu Y. Carbon dots/gC3N4/ZnO nanocomposite as efficient visible-light driven photocatalyst for tetracycline total degradation. Separation and Purification Technology. 2017;173:295303.
  22.  Berkson ZJ, Messinger RJ, Na K, Seo Y, Ryoo R, Chmelka BF. Non-Topotactic Transformation of Silicate Nanolayers into Mesostructured MFI Zeolite Frameworks During Crystallization. Angewandte Chemie International Edition. 2017;56(19):5164-9.
  23.  Shu Y, He M, Ji J, Huang H, Liu S, Leung DY. Synergetic degradation of VOCs by vacuum ultraviolet photolysis and catalytic ozonation over Mn-xCe/ZSM-5. Journal of hazardous materials. 2019;364:770-9.
  24.  Saleem M, Atiq S, Naseem S, Siddiqi SA. Structural and magnetic studies of Ni-doped ZnO synthesized with autocombustion and co-precipitation techniques. Journal of the Korean Physical Society. 2012;60(10):1772-5.
  25.  Chu F, Zheng Y, Wen B, Zhou L, Yan J, Chen Y. Adsorption of toluene with water on zeolitic imidazolate framework-8/ graphene oxide hybrid nanocomposites in a humid atmosphere. RSC Advances. 2018;8(5):2426-32.
  26.  Li B, Liu T, Wang Y, Wang Z. ZnO/graphene-oxide nanocomposite with remarkably enhanced visible-lightdriven photocatalytic performance. Journal of colloid and interface science. 2012;377(1):114-21.
  27.  Nasrollahzadeh M, Jaleh B, Jabbari A. Synthesis, characterization and catalytic activity of graphene oxide/ ZnO nanocomposites. Rsc Advances. 2014;4(69):3671320.
  28.  Choi E-Y, Han TH, Hong J, Kim JE, Lee SH, Kim HW, et al. Noncovalent functionalization of graphene with endfunctional polymers. Journal of Materials Chemistry. 2010;20(10):1907-12.
  29.  Nethravathi C, Rajamathi M. Chemically modified graphene sheets produced by the solvothermal reduction of colloidal dispersions of graphite oxide. Carbon. 2008;46(14):1994-8.
  30.  Yan H, Jiang L, Xu X, Li Y, Shen Y, Zhu S. Ultrastrong composite film of Chitosan and silica-coated graphene oxide sheets. International journal of biological macromolecules. 2017;104:936-43.
  31.  Dhandapani B, Oyama ST. Gas phase ozone decomposition catalysts. Applied Catalysis B: Environmental. 1997;11(2):129-66.
  32.  Rezaei E, Soltan J, Chen N. Catalytic oxidation of toluene by ozone over alumina supported manganese oxides: effect of catalyst loading. Applied Catalysis B: Environmental. 2013;136:239-47.
  33.  Wang K-H, Jehng J-M, Hsieh Y-H, Chang C-Y. The reaction pathway for the heterogeneous photocatalysis of trichloroethylene in gas phase. Journal of hazardous materials. 2002;90(1):63-75.
  34.  Mehrizadeh H, Niaei A, Tseng H-H, Salari D, Khataee A. Synthesis of ZnFe 2 O 4 nanoparticles for photocatalytic removal of toluene from gas phase in the annular reactor. Journal of Photochemistry and Photobiology A: Chemistry. 2017;332:188-95.
  35.  Lewandowski M, Ollis D. Extension of a two-site transient kinetic model of TiO 2 deactivation during photocatalytic oxidation of aromatics: concentration variations and catalyst regeneration studies. Applied Catalysis B: Environmental. 2003;45(3):223-38.
  36.  Piera E, Ayllón JA, Doménech X, Peral J. TiO 2 deactivation during gas-phase photocatalytic oxidation of ethanol. Catalysis Today. 2002;76(2):259-70.
  37.  Hong Q, Sun D-z, CHI G-q. Formaldehyde degradation by UV/TiO 2/O 3 process using continuous flow mode. Journal of Environmental Sciences. 2007;19(9):1136-40.
  38.  Kwong C, Chao CYH, Hui K, Wan M. Catalytic ozonation of toluene using zeolite and MCM-41 materials. EnvironSciTechnol. 2008;42(22):8504-9.
  39.  Nath RK, Zain MFM, Kadhum AAH, Kaish A. An investigation of LiNbO 3 photocatalyst coating on concrete surface for improving indoor air quality. Construction and Building Materials. 2014;54:348-53.
  40. Twesme TM, Tompkins DT, Anderson MA, Root TW. Photocatalytic oxidation of low molecular weight alkanes: observations with ZrO 2–TiO 2 supported thin films. Applied Catalysis B: Environmental. 2006;64(3):153-60.
  41. Sleiman M, Conchon P, Ferronato C, Chovelon J-M. Photocatalytic oxidation of toluene at indoor air levels (ppbv): Towards a better assessment of conversion, reaction intermediates and mineralization. Applied Catalysis B: Environmental. 2009;86(3):159-65.
  42.  Ao C, Lee S. Indoor air purification by photocatalyst TiO 2 immobilized on an activated carbon filter installed in an air cleaner. Chemical engineering science. 2005;60(1):103-9.
  43.  Jo W-K. Coupling of graphene oxide into titania for purification of gaseous toluene under different operational conditions. Vacuum. 2014;99:22-5.
  44.  Rezaei F, Moussavi G, Bakhtiari AR, Yamini Y. Toluene removal from waste air stream by the catalytic ozonation process with MgO/GAC composite as catalyst. Journal of hazardous materials. 2016;306:348-58.
  45.  Jo W-K, Kim J-T. Application of visible-light photocatalysis with nitrogen-doped or unmodified titanium dioxide for control of indoor-level volatile organic compounds. Journal of hazardous materials. 2009;164(1):360-6.
  46.  Liu J, Yan Y, Zhang H. Adsorption dynamics of toluene in composite bed with microfibrous entrapped activated carbon. Chemical Engineering Journal. 2011;173(2):45662.
  47.  Giri RR, Ozaki H, Ishida T, Takanami R, Taniguchi S. Synergy of ozonation and photocatalysis to mineralize low concentration 2, 4-dichlorophenoxyacetic acid in aqueous solution. Chemosphere. 2007;66(9):1610-7.
  48.  Černigoj U, Štangar UL, Trebše P. Degradation of neonicotinoid insecticides by different advanced oxidation processes and studying the effect of ozone on TiO 2 photocatalysis. Applied Catalysis B: Environmental. 2007;75(3):229-38.
  49. Pengyi Z, Fuyan L, Gang Y, Qing C, Wanpeng Z. A comparative study on decomposition of gaseous toluene by O 3/UV, TiO 2/UV and O 3/TiO 2/UV. Journal of Photochemistry and Photobiology A: Chemistry. 2003;156(1):189-94.
Journal of Research in Environmental Health
Volume 7, Issue 1
Spring 2021
Pages 27-41